混凝土輸送管，應根據工程和施工場地特點、混凝土澆筑方案進行配管。宜縮短管線長度，少用彎管和軟管。輸送管的鋪設應保證安全施工，便于清洗管道、排除故障和裝拆維修。

在同一條管線中，應采用相同管徑的混凝土輸送管;同時采用新、舊管段時，應將新管布置在泵送壓力較大處;管線宜布置得橫平豎直。應繪制布管簡圖，列出各種管件、管連接環、彎管等的規格和數量，提出備件清單。混凝土輸送管應根據粗骨料最大粒徑、混凝土泵型號、混凝土輸出量的輸送距離，以及輸送難易程度等進行選擇。輸送管應具有與泵送條件相適應的強度。應使用無龜裂、無凹凸損傷和無彎折的管段。輸送管的接頭應嚴密，有足夠強度，并能快速裝拆。輸送管最小管徑為100mm時，粗骨料最大粒徑不能超過25mm，最小管徑為125mm時，最大粒徑不能超過40mm。

垂直向上配管時，地面水平管長度不宜小于垂直管長度的四分之一，且不宜小于15m，或遵守產品說明書中的規定。在混凝土泵機Y形管出料口3~6m處的輸送管根部應設置截止閥，以防混凝土拌和物反流。

泵送施工地下結構物時，地上水平管軸線應與Y形管出料口軸線垂直。傾斜向下配管時，應在斜管上端設排氣閥;當高差大于20m時，應在斜管下端下設5倍高差長度的水平管;如條件限制，可增加彎管或環形管，滿足5倍高差長度要求。

混凝土輸送管的固定，不得直接支承在鋼筋、模板及預埋件上，水平管宜每隔一定距離用支架、臺墊、吊具等固定，以便于排除堵管、裝拆和清洗管道;垂直管宜用預埋件固定在墻和柱或樓板頂留孔處。在墻及柱上，每節管不得少于1個固定點，在每層樓板預留孔處均應固定。垂直管下端的彎管，不應作為上部管道的支撐點。宜設鋼支撐承受垂直管重量。當垂直管固定在腳手架上時，根據需要可對腳手架進行加固。管道接頭卡箍處不得漏漿。

炎熱季節施工，宜用濕罩布、溫草袋等遮蓋混凝土輸送管，避免陽光照射。嚴寒季節施工，宜用保溫材料包裹}昆凝土輸送管，防止管內混凝土受凍，并保證混凝土的入模溫度。

當水平輸送距離超過200m，垂直輸送距離超過40m，輸送管垂直向下或斜管前面布置水平管，混凝土拌和物單位水泥用量低于300kg/m³時，必須合理選擇配管方法和泵送工藝，宜用直徑大的混凝土輸送管和長的錐形管，少用彎管和軟管。當輸送高度超過混凝土泵的最大輸送距離時，可用接力泵(后繼泵)進行泵送。

此外，還應根據工程結構特點、施工工藝、布料要求和配管情況等，選擇布料設備。應根據結構平面尺寸、配管情況和布料桿長度，布置布料設備，且其應能覆蓋整個結構平面，并能均勻、迅速地進行布料。布料設備應安設牢固和穩定。

科瑪森全面承接安徽佳樂混凝土細石泵產品售后及產品升級！

更多詳情，請咨詢138 7483 9997（微信同號）或0731-8563 9997

使用科瑪森品牌，讓別人聽你成功的故事……